Any way to combat crumble dust?

[cluckingheck]

So, I recently switched to pellets because the dust from the crumble feed was causing my chooks to sneeze. They’re eating the pellets with no sneezing, but they definitely aren’t as enthralled. i had a broody hatch chicks close to four weeks ago and this wasn’t a problem at first because I kept the brooder door closed until the chicks were a little over a week old, but since I’ve opened the door everyone wants to eat the chicks’ food when mom takes them outside the coop.

the chick starter isn’t dusty, though when I switch back to the big chickens’ crumbles, is there anyway to reduce the dust so i don’t have a repeat of the sneezing? would i have to sift it?

 

[aart]

though when I switch back to the big chickens’ crumbles,

What brand?
Might try a different brand.
Is it fresh.....check mill date.

Crumble is inherently dustier than pellets.
Don't really have a problem with it here, they eat it all.....and yes, sometimes they sneeze.

 

[U_Stormcrow]

Echoing Wet Feed/Wet Mash (personal preference). Easy fix. FRESH is ALWAYS the rule, whether you use pellet, crumble, or whole grains.

 

[cavemanrich]

Consider making it a WET FEED. Not same as fermented feed.
I use pellets, and one reason is,,,,, very little waste. The pellets do get picked up. When feed is like a powder, chickens do not pick it up.
WISHING YOU BEST,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,

 

[NatJ]

the chick starter isn’t dusty, though when I switch back to the big chickens’ crumbles, is there anyway to reduce the dust so i don’t have a repeat of the sneezing?

You could serve them all chick starter. It's fine for chickens of all ages.

Just be sure to have a separate dish of oyster shell, so the layers can get the extra calcium they need. (Chickens are usually good at eating the right amount of oyster shell for their needs.)

 

[cluckingheck]

You could serve them all chick starter. It's fine for chickens of all ages.

Just be sure to have a separate dish of oyster shell, so the layers can get the extra calcium they need. (Chickens are usually good at eating the right amount of oyster shell for their needs.)

I thought about that, but I also have 4 ducks ( 16 weeks old ). I never thought to mention them because they never had an issue with sneezing. Though, I don’t think the ducks would change much. And I already have a dish of oyster shells out because I have both cockerels and pullets in the same flock, so I was using flock raiser instead of layer feed.

So, yeah, it probably wouldn’t hurt just to switch to chick food until their old enough. The chicks are already around 4 weeks old

 

[U_Stormcrow]

I used the Purina Flock Raiser several times this year, yeah, it was dusty. The Pellets really were my favorite, but I found a local mill which allows me to get fresher feed, MUCH cheaper - but only as crumble. That's when I started the wet food/wet mash routine (which really depends mostly on when I remembered to prepare the 5 gal feed buckets, and how many I started at a time.

Handling of those bags doesn't help any of the product, I've had the Nutrena Pellet this year almost half crumble too. Not all of it is in the control of the store.

 

[U_Stormcrow]

Doesn’t wet feed run the risk of molding? I have their food in hanging feeders and offered at all times.

Nope. Or maybe, depends on how you do it.

I have 5 gallon buckets, and am mixing crumble from two bags to make my feed for my flock. 2 scoops of 24% game bird feeder, 1 scoop of 16% layer, repeat, 2 more scoops of 24% game bird. Gives me a 22% protein mix at about 1.5% calcium ( a little higher than I want, honestly) at a cost of about $0.23-0.27/lb (prices just went up). Anyhow, that's 9# of feed to a bucket and fills it about 2/3. Mix, then add water up to the first ring near the top, leaving about 1 1/2" of "head space". Lid, loosely. Set aside two days, mixing periodically. That will feed my flock for three days. I usually prepare two buckets at a time, its never more than 10-12 days when served, usually closer to 5-7. Because its covered by water the whole time, no mold or mildew.

If I don't have enough water, don't mix well, and leave it in the run (which I sometimes do), the last day can turn a little grey on the surface - like oatmeal left next to the sink for a day, but that's it. and I'm in FL, typically hot and humid.

If I had a much smaller flock, then yes, the quantities I make might go moldy with time.


/edit to add Yes, I free choice oyster shell and grit, two locations of each - though my birds seem to get plenty of grit from free ranging the property.

Also, my birds free range all day, with the choice to roam about 4.5 acres, protected by electric fencing. I feed them once daily by scooping the wet feed/wet mash into plastic rain gutters before they settle in for the evening, as an incentive to come to the run before sunset.

 

[Onyxflock]

So, I recently switched to pellets because the dust from the crumble feed was causing my chooks to sneeze. They’re eating the pellets with no sneezing, but they definitely aren’t as enthralled. i had a broody hatch chicks close to four weeks ago and this wasn’t a problem at first because I kept the brooder door closed until the chicks were a little over a week old, but since I’ve opened the door everyone wants to eat the chicks’ food when mom takes them outside the coop.

the chick starter isn’t dusty, though when I switch back to the big chickens’ crumbles, is there anyway to reduce the dust so i don’t have a repeat of the sneezing? would i have to sift it?

I switched back to crumble as well, my hens didn't take to the pellets that well. But I changed style of feeders, and this one allows the chunks to fall into the feeding area on top of the dust. When feed gets low, I shake it all out into a bag and refill with new feed. We use the bag of dust to mix with water to make a mash for their evening treat. Also on cold mornings, use warm water to mix along with a sprinkle of oats.
You might remove access to the chick starter when they're out to free range. Chickens are notorious opportunists.

 

[cluckingheck]

Nope. Or maybe, depends on how you do it.

I have 5 gallon buckets, and am mixing crumble from two bags to make my feed for my flock. 2 scoops of 24% game bird feeder, 1 scoop of 16% layer, repeat, 2 more scoops of 24% game bird. Gives me a 22% protein mix at about 1.5% calcium ( a little higher than I want, honestly) at a cost of about $0.23-0.27/lb (prices just went up). Anyhow, that's 9# of feed to a bucket and fills it about 2/3. Mix, then add water up to the first ring near the top, leaving about 1 1/2" of "head space". Lid, loosely. Set aside two days, mixing periodically. That will feed my flock for three days. I usually prepare two buckets at a time, its never more than 10-12 days when served, usually closer to 5-7. Because its covered by water the whole time, no mold or mildew.

If I don't have enough water, don't mix well, and leave it in the run (which I sometimes do), the last day can turn a little grey on the surface - like oatmeal left next to the sink for a day, but that's it. and I'm in FL, typically hot and humid.

If I had a much smaller flock, then yes, the quantities I make might go moldy with time.


/edit to add Yes, I free choice oyster shell and grit, two locations of each - though my birds seem to get plenty of grit from free ranging the property.

Also, my birds free range all day, with the choice to roam about 4.5 acres, protected by electric fencing. I feed them once daily by scooping the wet feed/wet mash into plastic rain gutters before they settle in for the evening, as an incentive to come to the run before sunset.

I should probably mention how big my flock is. 23 big chickens, 3 chicks & 4 ducks. Occasionally two goats when they decide to break into the chicken coop and eat as much feed from the feeders as they can. Mine free range too and I leave the food in the coop as free choice for them.

I don’t know if I should change how I feed them if I’m wanting to wet the feed. I haven’t had any problems with them not wanting to return to the coop at bedtime ( yet ). Anyways, thanks for this, it’s definitely helpful